Lincoln Corsair Manuals

Lincoln Corsair: Front Disc Brake / Removal and Installation - Brake Disc Shield

Lincoln Corsair 2020-2025 Service Manual / Chassis / Brake System / Front Disc Brake / Removal and Installation - Brake Disc Shield

Removal

NOTE: Removal steps in this procedure may contain installation details.

  1. Remove the brake disc.
    Refer to: Brake Disc (206-03 Front Disc Brake, Removal and Installation).
  1. Remove the bolts and brake disc.
    Torque: 80 lb.in (9 Nm)

Installation

  1. To install, reverse the removal procedure.

    Removal and Installation - Brake Disc

    Materials Name Specification Motorcraft® Metal Brake Parts CleanerPM-4-A, PM-4-B, APM-4-C -  Removal   WARNING: Service actions on vehicles equipped with electronic brake booster and electronic parking brakes may cause unexpected brake application, which could result in injury to hands or fingers...

    Removal and Installation - Brake Pads

    Materials Name Specification Motorcraft® Silicone Brake Caliper Grease and Dielectric CompoundXG-3-A ESA-M1C200-AESE-M1C171-A  Motorcraft® Metal Brake Parts CleanerPM-4-A, PM-4-B, APM-4-C -  Removal   WARNING: Service actions on vehicles equipped with electronic brake booster and electronic parking brakes may cause unexpected brake application, wh..

    Other information:

    Lincoln Corsair 2020-2025 Service Manual: Removal and Installation - Rear Seat


    Special Tool(s) / General Equipment Interior Trim Remover Removal   WARNING: The following procedure describes critical repair steps required for correct seat component installation. Follow all notes and steps carefully. Do not place any objects between the seat components and the body of the vehicle, nor any objects within a joint internal to the seat structure. Failure t..

    Lincoln Corsair 2020-2025 Service Manual: Removal and Installation - Intake Manifold


    Removal NOTICE: The turbocharger compressor vanes can be damaged by even the smallest particles. When removing any turbocharger or engine air intake system component, ensure that no debris enters the system. Failure to do so may result in damage to the turbocharger. With the vehicle in NEUTRAL, position it on a hoist. Refer to: Jacking and Lifting - Overview (100-02 Jacking and ..

    Categories

    Keyless Starting

    Note: The keyless starting system may not function if the key is close to metal objects or electronic devices such as cellular phones.

    Note: A valid key must be located inside your vehicle to switch the ignition on and start the engine.

    Ignition Modes

    Lincoln Corsair. Keyless Starting

    read more

    Copyright © 2025 www.licorsair.com