Lincoln Corsair Manuals

Lincoln Corsair: Interior Trim and Ornamentation / Removal and Installation - Front Door Trim Panel

Special Tool(s) / General Equipment

Pick Hook
Interior Trim Remover

Removal

NOTE: LH (left hand) shown, RH (right hand) similar.

NOTE: Removal steps in this procedure may contain installation details.

  1. Release the clips and remove the interior front door handle bolt cover.
    Use the General Equipment: Pick Hook
  1. Remove the interior front door handle bolt.
    Torque: 17 lb.in (1.9 Nm)
  1. Remove the window control switch.
    Refer to: Driver Door Window Control Switch (501-11 Glass, Frames and Mechanisms, Removal and Installation).
    Refer to: Passenger Door Window Control Switch (501-11 Glass, Frames and Mechanisms, Removal and Installation).
  1. Remove the front door trim panel bolt.
    Torque: 22 lb.in (2.5 Nm)
  1. Release the tab and remove the front door trim panel bolt cover.
    Use the General Equipment: Pick Hook
  1. Remove the front door trim panel bolt.
    Torque: 8 lb.in (0.9 Nm)
  1. Remove the front door trim panel lower bolts.
    Torque: 13 lb.in (1.5 Nm)
  1. Release the front door trim panel clips.
    Use the General Equipment: Interior Trim Remover

  1. Remove the front door trim panel.
    1. Release the tabs and position the interior front door cable aside.
    1. Disconnect the front seat control switch electrical connector.
    1. If equipped.
      Disconnect the front door tweeter speaker electrical connector.
    1. Disconnect the door lock indicator electrical connector.

Installation

  1. NOTE: Transfer parts as necessary.

    To install, reverse the removal procedure.

    Removal and Installation - D-Pillar Trim Panel

    Special Tool(s) / General Equipment Interior Trim Remover Removal NOTE: LH (left hand) shown, RH (right hand) similar. NOTE: Rear seats removed for clarity...

    Removal and Installation - Front Scuff Plate Trim Panel

    Special Tool(s) / General Equipment Interior Trim Remover Removal NOTE: LH (left hand) shown, RH (right hand) similar. Release the clips and remove the instrument panel side trim panel...

    Other information:

    Lincoln Corsair 2020-2023 Service Manual: Removal and Installation - Windshield Washer Fluid Level Sensor


    Materials Name Specification Motorcraft® Premium Windshield Wash Concentrate with BitterantZC-32-B2 WSS-M14P19-A  Removal Remove the windshield washer reservoir. Refer to: Windshield Washer Reservoir (501-16 Wipers and Washers, Removal and Installation)...

    Lincoln Corsair 2020-2023 Service Manual: Removal and Installation - Fuel Filler Door Assembly


    Special Tool(s) / General Equipment Flat Headed Screw Driver Knife Removal NOTE: Removal steps in this procedure may contain installation details. NOTE: The fuel filler door assembly is damaged during the removal process and requires a new fuel filler door assembly installed...

    Categories

    Audio Unit

    WARNING: Driving while distracted can result in loss of vehicle control, crash and injury. We strongly recommend that you use extreme caution when using any device that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any hand-held device while driving and encourage the use of voice-operated systems when possible. Make sure you are aware of all applicable local laws that may affect the use of electronic devices while driving.

    Lincoln Corsair. Audio Unit

    read more

    Copyright © 2023 www.licorsair.com