Lincoln Corsair: Rear Drive Axle/Differential / Removal and Installation - Rear Drive Unit (RDU) Actuator Motor
Removal
-
Remove the rear axle assembly.
Refer to: Axle Assembly (205-02A) .
-
NOTICE: The RDU contains axle fluid. To prevent spillage, do not tilt the RDU during actuator motor removal or installation.
NOTE: Mark the installation orientation prior to removal with a marker.
Remove and discard the bolts. Remove the actuator motor.
 |
Installation
-
Make sure that the idler gear and spline teeth are aligned before tightening the bolts.
 |
-
NOTICE: Make sure new bolts are used.
NOTE: The RDU bolts must be started by hand prior to tightening.
Install the bolts and the actuator motor.
Torque: 133 lb.in (15 Nm)
 |
-
Install the rear axle assembly.
Refer to: Axle Assembly (205-02A) .
Removal and Installation - Drive Pinion Seal
Special Tool(s) /
General Equipment
205-208
(T83T-4676-A)
Installer, Drive Pinion Oil SealTKIT-1983-FTKIT-1983-FLMTKIT-1983-FX
Flat Headed Screw Driver
Materials
Name
Specification
Motorcraft® Premium Long-Life GreaseXG-1-E1
ESA-M1C75-B
Removal
Remove the drive pinion flange...
Removal and Installation - Rear Drive Unit (RDU) Speed Sensor
Materials
Name
Specification
Motorcraft® Disconnect Rear Drive Unit FluidXY-75W-QL
-
Removal
NOTE:
Removal steps in this procedure may contain installation details...
Other information:
Lincoln Corsair 2020-2025 Owners Manual: Using Lap and Shoulder Belts
WARNING: Do not place a rearward facing child restraint in front of an active airbag. Failure to follow this instruction could result in personal injury or death. WARNING: Properly secure children 12 years old and under in a rear seating position whenever possible...
Lincoln Corsair 2020-2025 Service Manual: Removal and Installation - Exterior Front Door Handle Reinforcement
Removal NOTE: LH (left-hand) side shown, RH (right-hand) side similar. Remove the front door latch. Refer to: Front Door Latch (501-14 Handles, Locks, Latches and Entry Systems, Removal and Installation). NOTE: This step is only necessary when installing a new component...
Categories
- Manuals Home
- 1st Generation Lincoln Corsair Owners Manual
- 1st Generation Lincoln Corsair Service Manual
- Memory Function
- Capacities and Specifications - 2.0L
- Changing a Road Wheel
- New on site
- Most important about car
Audio Unit
WARNING: Driving while distracted can result in loss of vehicle control, crash and injury. We strongly recommend that you use extreme caution when using any device that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any hand-held device while driving and encourage the use of voice-operated systems when possible. Make sure you are aware of all applicable local laws that may affect the use of electronic devices while driving.
