Lincoln Corsair: Fuel Charging and Controls - 2.0L EcoBoost (177kW/240PS) – MI4 / Removal and Installation - High-Pressure Fuel Pump Drive Unit
Lincoln Corsair 2020-2024 Service Manual / Powertrain / Engine / Fuel Charging and Controls - 2.0L EcoBoost (177kW/240PS) – MI4 / Removal and Installation - High-Pressure Fuel Pump Drive Unit
Removal
-
Remove the valve cover.
Refer to: Valve Cover (303-01A Engine - 2.0L EcoBoost (177kW/240PS) – MI4, Removal and Installation).
-
Remove the high-pressure fuel pump drive unit bolts, then remove the high-pressure fuel pump drive unit.
 |
Installation
-
Make sure that the mating faces are clean and free of
corrosion and foreign material. Install the high-pressure fuel pump
drive unit, then install and tighten the high-pressure fuel pump drive
unit bolts.
Torque: 97 lb.in (11.0 Nm)
|
-
Install the valve cover.
Refer to: Valve Cover (303-01A Engine - 2.0L EcoBoost (177kW/240PS) – MI4, Removal and Installation).
Removal and Installation - High-Pressure Fuel Pump
Removal
NOTICE:
Do not loosen any fittings or plugs on the high-pressure fuel pump.
With the vehicle in NEUTRAL, position it on a hoist.
Refer to: Jacking and Lifting - Overview (100-02 Jacking and Lifting, Description and Operation)...
Removal and Installation - Throttle Body
Removal
Remove the charge air cooler (CAC) outlet pipe.
Refer to: Charge Air Cooler (CAC) Outlet Pipe (303-12A Intake Air
Distribution and Filtering - 2...
Other information:
Lincoln Corsair 2020-2024 Service Manual: Removal and Installation - Rear Subframe
Special Tool(s) / General Equipment 300-OTC1585AEPowertrain Lift Wooden Block Removal NOTICE: Suspension fasteners are critical parts that affect the performance of vital components and systems. Failure of these fasteners may result in major service expense...
Lincoln Corsair 2020-2024 Service Manual: Diagnosis and Testing - Variable Camshaft Timing (VCT) System
Diagnostic Trouble Code (DTC) Chart Diagnostics in this manual assume a certain skill level and knowledge of Ford-specific diagnostic practices.REFER to: Diagnostic Methods (100-00 General Information, Description and Operation). Module DTC Description Action PCM P000A:00 'A' Camshaft Position Slow Response (Bank 1): No Sub Type Information GO to Pinpoint Test HK PCM P000B..
Categories
- Manuals Home
- 1st Generation Lincoln Corsair Owners Manual
- 1st Generation Lincoln Corsair Service Manual
- Selecting a Drive Mode. DRIVE MODES
- Automatic Transmission - 8-Speed Automatic Transmission – 8F35/8F40
- Auto Hold (IF EQUIPPED)
- New on site
- Most important about car
USB Port
WARNING: Driving while distracted can result in loss of vehicle control, crash and injury. We strongly recommend that you use extreme caution when using any device that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any hand-held device while driving and encourage the use of voice-operated systems when possible. Make sure you are aware of all applicable local laws that may affect the use of electronic devices while driving.
USB A
Copyright © 2024 www.licorsair.com