Lincoln Corsair Manuals

Lincoln Corsair: Fuel Charging and Controls - 2.0L EcoBoost (177kW/240PS) – MI4 / Removal and Installation - Fuel Pump Driver Module (FPDM)

Removal

NOTE: The fuel pump driver module is attached to the top of the fuel tank.

  1. For component location information.
    Refer to: Fuel Charging and Controls - Component Location (303-04A Fuel Charging and Controls - 2.0L EcoBoost (177kW/240PS) – MI4, Description and Operation).
    Refer to: Fuel Charging and Controls - Component Location (303-04B Fuel Charging and Controls - 2.3L EcoBoost (199kW/270PS), Description and Operation).
  1. Remove the fuel tank.
    Refer to: Fuel Tank (310-01A Fuel Tank and Lines - 2.0L EcoBoost (177kW/240PS) – MI4, Removal and Installation).
    Refer to: Fuel Tank (310-01B Fuel Tank and Lines - 2.3L EcoBoost (199kW/270PS), Removal and Installation).
  1. Disconnect the fuel pump driver module electrical connector.
  1. Release the fuel pump driver module retaining tab, then remove the fuel pump driver module from the bracket.

Installation

  1. Install the fuel pump driver module to the bracket until it clicks and locks into position.
  1. Connect the fuel pump driver module electrical connector.
  1. Install the fuel tank.
    Refer to: Fuel Tank (310-01A Fuel Tank and Lines - 2.0L EcoBoost (177kW/240PS) – MI4, Removal and Installation).
    Refer to: Fuel Tank (310-01B Fuel Tank and Lines - 2.3L EcoBoost (199kW/270PS), Removal and Installation).

    Removal and Installation - Fuel Injectors

    Removal and Installation The fuel injectors are removed with the fuel rail. Refer to: Fuel Rail (303-04B Fuel Charging and Controls - 2.3L EcoBoost (199kW/270PS), Removal and Installation)...

    Removal and Installation - Fuel Rail

    Special Tool(s) / General Equipment 303-1567Sizer, Teflon SealTKIT-2010C-FLM 307-005 (T59L-100-B) Slide Hammer 310-205Fuel Injector Brush 310-206Remover, Fuel InjectorTKIT-2009A-FLM 310-207Installer, Fuel Injector Seal AssemblyTKIT-2009A-FLM Removal Release the fuel system pressure...

    Other information:

    Lincoln Corsair 2020-2024 Service Manual: Removal and Installation - Auto-Start-Stop Accumulator


    Special Tool(s) / General Equipment 307-771Accumulator Release Pin Materials Name Specification Petroleum Jelly -  Removal Remove the battery tray. Refer to: Battery Tray - 2.0L EcoBoost (177kW/240PS) – MI4/2...

    Lincoln Corsair 2020-2024 Service Manual: Removal and Installation - Interior Rear View Mirror


    Special Tool(s) / General Equipment Interior Trim Remover Removal NOTE: Removal steps in this procedure may contain installation details. NOTE: Interior rear view mirror removed for clarity. Remove the IPMA cover. Release the IPMA clips and the tether clip from the IPMA cover...

    Categories

    Audio Unit

    WARNING: Driving while distracted can result in loss of vehicle control, crash and injury. We strongly recommend that you use extreme caution when using any device that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any hand-held device while driving and encourage the use of voice-operated systems when possible. Make sure you are aware of all applicable local laws that may affect the use of electronic devices while driving.

    Lincoln Corsair. Audio Unit

    read more

    Copyright © 2024 www.licorsair.com